Engine Mechanical:
Detailed breakdown of engine components, cylinder head, block, crankshaft, camshaft, timing, etc.
Emission Control:
Catalytic converter, oxygen sensors, exhaust gas recirculation (EGR) system
Efi System:
Electronic Fuel Injection system diagnostics, components (injectors, fuel pump, sensors), and operation
Lubrication System:
Oil pump, oil filter, oil pressure, oil capacity and specifications
Cooling System:
Radiator, water pump, thermostat, coolant types and capacity, cooling fan operation
Ignition System:
Spark plugs, ignition coils, ignition timing, distributor (if applicable)
Starting System:
Starter motor, battery, ignition switch operation
Charging System:
Alternator, voltage regulator, battery charging diagnostics
Clutch:
Clutch disc, pressure plate, release bearing, hydraulic system, adjustments
Manual Transmission:
Gearbox components, shift mechanism, fluid types and capacity, repair procedures
Automatic Transmission:
Transmission operation, fluid specifications, service, and repair (if applicable to specific models covered)
Transmission And Transfer:
Transfer case operation, maintenance, and repair, 4WD system components
Propeller Shaft:
Driveshaft inspection, U-joints, balancing
Front And Rear Differential:
Differential gear inspection, fluid types and capacity, servicing
Front Axle And Suspension:
Front suspension components (struts, shocks, bushings, ball joints), alignment, steering knuckles
Rear Axle And Suspension:
Rear suspension components (leaf springs, shocks, trailing arms), axle housing inspection
Brake Including ABS:
Brake system diagnostics, disc brakes (pads, rotors), drum brakes, brake fluid specifications and bleeding procedures, ABS system components and troubleshooting
Steering:
Steering column, power steering system (pump, rack/box), tie rods, steering wheel removal
Body:
Body panel repair, door mechanisms, interior trim, glass replacement, rust prevention
Body Electrical:
Lighting system, power windows, central locking, wipers, horn, fuses, relays
Harness And Wiring Diagram:
Detailed wiring diagrams for all electrical systems, troubleshooting using wiring schematics
Maintenance:
Regular servicing, fluid changes, filter replacements, inspections
Repair:
Component-level repair and replacement for all major systems
Diagnostics:
Troubleshooting common issues, diagnostic procedures for EFI and electrical systems
Rebuilds:
Overhaul and rebuild procedures for engine, transmission, and differentials
Depth:
Detailed technical specifications, torque values, tolerances, diagnostic trouble codes (DTCs) if applicable, repair procedures from basic to advanced
Oil Change Interval:
Typically every 5,000-10,000 km or 6-12 months, depending on driving conditions and oil type. Consult manual for specifics.
Transmission Fluid Interval:
Manual: Check periodically, change every 40,000-60,000 km. Automatic: Check regularly, change every 40,000-50,000 km.
Coolant Change Interval:
Every 2-3 years or 40,000-60,000 km.
Engine Oil Type:
API SG/SH/SJ or higher, viscosity typically 10W-30 or 5W-30 depending on climate. Check manual for exact specification.
Transmission Fluid Manual:
GL-4 gear oil, viscosity 75W-90 or 80W-90.
Transmission Fluid Automatic:
Dexron III equivalent ATF.
Brake Fluid:
DOT 3 or DOT 4.
Coolant:
Ethylene glycol based antifreeze mixed with distilled water (50/50 ratio). Refer to manual for specific type.
Common Wear Items:
Suspension bushings, ball joints, tie rod ends, clutch wear, exhaust system rust, radiator hoses.
Engine Concerns:
Minor oil leaks from gaskets, occasional ignition coil failure on older models.
4Wd System Concerns:
Transfer case bushings, propeller shaft U-joints can wear with high mileage and off-road use.
