Engine:
Complete engine service, diagnostics, and repair for all available powertrains.
Control System:
Engine control modules (ECM), Powertrain control modules (PCM) diagnostics and programming.
Mechanical:
Detailed mechanical component repair including valve train, piston assemblies, crankshaft, etc.
Fuel Service Specifications:
Fuel system diagnosis, pump, injector, and pressure specifications.
Emission Control:
Emission system diagnosis, catalytic converter, O2 sensors, EVAP system.
Intake Exhaust Cooling:
Cooling system diagnosis, radiator, water pump, thermostat, exhaust manifold, muffler.
Lube:
Lubrication system diagnosis, oil pump, oil filter specifications, oil change procedures.
Ignition Starting Charging:
Ignition system components, spark plugs, coils, starter motor, alternator, battery testing.
Auto Transmission Clutch:
Automatic transmission diagnosis, repair, fluid specifications, torque converter.
Manual Transmission:
Manual transmission diagnosis, repair, clutch replacement, fluid specifications.
Transfer Propeller Shaft:
Driveshaft and U-joint service (if applicable to specific Verano models).
Drive Shaft:
Front axle drive shafts, CV joints, and boots.
Differential:
Front differential service and repair (if applicable).
Axle Suspension:
Front and rear suspension components, alignment, shock absorbers, struts, control arms.
Tire Wheel:
Tire pressure monitoring system (TPMS), wheel bearing replacement, tire rotation.
Brake Control:
ABS system diagnosis, control module, brake fluid specifications.
Brake:
Brake pad replacement, rotor resurfacing/replacement, caliper service, brake bleeding.
Parking Brake:
Parking brake system adjustment and repair.
Steering Column:
Steering column repair, tilt/telescope adjustments, ignition switch replacement.
Power Steering:
Power steering system diagnosis, pump, rack and pinion, fluid type.
Air Condition:
HVAC system diagnosis, refrigerant recharge, compressor, condenser, evaporator service.
Suppl Restraint System:
Airbag system diagnosis, SRS module, sensor replacement, seat belt pretensioners.
Seat Belt:
Seat belt diagnosis, replacement, and anchor point service.
Engine Immobilizer:
Immobilizer system troubleshooting and programming.
Cruise Control:
Cruise control system diagnosis and repair.
Wiper Washer:
Wiper motor, linkage, washer pump, and fluid reservoir service.
Door Lock:
Power door lock actuator replacement, central locking system diagnosis.
Meter Audio Visual:
Instrument cluster diagnosis, infotainment system repair, speaker replacement.
Horn:
Horn system diagnosis and repair.
Windshield Glass Mirror:
Windshield replacement, power mirror service, window regulator repair.
Instrument Panel:
Instrument panel removal and installation, gauge cluster repair.
Seat:
Seat adjustment mechanisms, power seat repair, seat heating/cooling elements.
Engine Hood Door:
Hood latch and cable service, door hinge adjustment, door panel removal.
Exterior Interior:
Body panel repair, trim piece replacement, interior component installation.
Electrical:
General electrical system troubleshooting, fuse box diagrams, lighting systems.
Multiplex Can Communication:
CAN bus communication diagnosis, module integration, network troubleshooting.
Maintenance Procedures:
Scheduled maintenance, fluid checks and changes, filter replacements, inspections.
Diagnostic Procedures:
Troubleshooting guides, diagnostic trouble codes (DTCs) interpretation, symptom-based diagnosis.
Repair Procedures:
Step-by-step repair instructions for all major vehicle systems.
Installation Procedures:
Component replacement and installation guides.
Wiring Schematics:
Detailed electrical wiring diagrams for all vehicle circuits.
Depth Of Information:
Factory level detail, equivalent to technician manuals used at dealerships.
Diagnostic Tools:
Implied use of GM factory diagnostic tools (e.g., Tech 2, GDS2) for certain procedures.
Oil Change Interval:
Every 7,500 miles or 12 months (whichever comes first), using synthetic oil.
Tire Rotation Interval:
Every 7,500 miles.
Cabin Air Filter Replacement:
Every 20,000 miles or 24 months.
Transmission Fluid Change:
Inspect every 45,000 miles, change as needed or at severe service intervals.
Engine Oil Specification:
SAE 5W-30, GM dexos1™ approved synthetic oil.
Coolant Specification:
GM P/N 12346660 (Orange), Dex-Cool Extended Life Coolant (50/50 mixture).
Transmission Fluid Specification:
Dexron VI Automatic Transmission Fluid.
Common Issues 2012:
Potential issues include early wear on the front suspension bushings, water pump leaks, and sometimes electrical glitches with the infotainment system. Engine oil consumption can be a concern on some 2.4L engines.
