Engine Mechanical:
Complete engine overhaul, rebuilding, and component replacement
Intake System:
Turbocharger, intercooler, intake manifold, air filter housing, vacuum lines
Exhaust System:
Exhaust manifold, catalytic converter, muffler, exhaust pipes
Lubrication System:
Oil pump, oil pan, oil filter, oil passages, lubrication specifications
Cooling System:
Radiator, water pump, thermostat, coolant hoses, cooling fan, capacities
Fuel System:
Fuel pump, fuel injectors, fuel rail, fuel filter, pressure regulator
Engine Control System:
ECU, sensors (MAP, MAF, O2, TPS, ECT), actuators, diagnostic trouble codes (DTCs)
Emission Control:
EGR system, EVAP system, emission control strategies
Ignition System:
Spark plugs, ignition coils, ignition timing
Starting Charging System:
Starter motor, alternator, battery, charging system diagnostics
Engine Mounting:
Engine mounts, transmission mounts, vibration damping
Suspension:
Front and rear suspension components, shock absorbers, springs, bushings, alignment
Wheel Tires:
Wheel specifications, tire sizes, pressure recommendations, bolt pattern
Driveshaft Axle:
Front and rear driveshafts, CV joints, axles
Propeller Shaft:
If applicable (typically for RWD/AWD, less so for FWD Copen)
Brake System:
Brake discs, pads, calipers, master cylinder, brake lines, ABS system
Clutch:
Clutch disc, pressure plate, release bearing, clutch hydraulics
Manual Transmission:
Gearbox overhaul, shift mechanism, clutch operation, transmission fluid
Steering:
Steering column, steering rack, tie rods, steering linkage
Power Steering:
Power steering pump, fluid reservoir, hydraulic lines, steering assist
Airbag System:
Airbag modules, SRS control unit, sensors, diagnostic procedures
Body Accessories:
Body panel repair, trim, interior fittings
Exterior Interior:
Bodywork, doors, hood, trunk lid, seats, dashboard, trim panels
Wiper Washer:
Wiper motor, washer pump, wiper blades, washer fluid system
Audio Visual System:
Radio, speakers, antenna, head unit removal and installation
Heater Air Conditioner:
HVAC system components, blower motor, A/C compressor, refrigerant, controls
Wiring Diagram:
Complete electrical system schematics, component location diagrams
Maintenance:
Scheduled maintenance, fluid changes, filter replacements, general upkeep
Troubleshooting:
Diagnostic procedures, symptom analysis, problem identification
Repair:
Step-by-step instructions for component repair and replacement
Disassembly Assembly:
Complete vehicle disassembly and reassembly instructions
Specifications:
Torque specifications, clearances, fluid capacities, diagnostic values
Depth:
Comprehensive, from basic maintenance to advanced diagnostics and rebuilds
Oil Change Interval:
Typically 7,500 - 10,000 km (4,500 - 6,000 miles) or 6-12 months, refer to manual for specifics
Transmission Fluid Change:
Refer to manual; often 40,000 - 60,000 km (25,000 - 37,000 miles)
Engine Oil:
Refer to manual, typically 0W-20 or 5W-30 synthetic oil
Coolant:
Ethylene Glycol based, 50/50 mix with distilled water
Brake Fluid:
DOT 3 or DOT 4
Common Wear Items:
Turbocharger seals, suspension bushings, ignition coils
Retractable Roof:
Potential issues with hydraulics, seals, and motors if not maintained
