Engine Mechanical:
Full Engine Overhaul, Component Repair, Timing
Emission Control:
System Components, Diagnosis, and Repair
Efi System:
Fuel Injection, Sensors, Actuators, Control Module Diagnosis
Lubrication System:
Oil Pump, Passages, Oil Filter Replacement, Oil Viscosity Specifications
Cooling System:
Radiator, Water Pump, Thermostat, Coolant Specifications, Bleeding Procedures
Ignition System:
Spark Plugs, Coils, Ignition Timing, Troubleshooting
Starting System:
Starter Motor, Solenoid, Battery Testing
Charging System:
Alternator, Voltage Regulator, Battery Charging Specifications
Clutch:
Clutch Disc, Pressure Plate, Release Bearing, Hydraulic System
Manual Transmission:
Gearbox Components, Shifting Mechanisms, Fluid Specifications
Automatic Transmission:
Transmission Internals, Valve Body, Torque Converter, Fluid Types and Levels
Transmission And Transfer:
4WD System Operation, Transfer Case Servicing, Differential Servicing
Propeller Shaft:
U-Joints, Balancing, Removal and Installation
Front And Rear Differential:
Gearing, Bearings, Lubrication, Axle Ratios
Front Axle And Suspension:
Struts, Control Arms, Bushings, Alignment Specifications
Rear Axle And Suspension:
Shock Absorbers, Springs, Bushings, Alignment Specifications
Brake:
Front and Rear Brakes, Disc/Drum Servicing, Parking Brake
ABS System:
ABS Modulator, Wheel Speed Sensors, Diagnostic Procedures
Steering:
Power Steering Pump, Rack and Pinion, Tie Rods, Alignment
Body:
Body Panel Replacement, Structural Repair, Sealing
Body Electrical:
Lighting, Wipers, Power Accessories, Door Locks
Airbag System:
SRS Components, Airbag Module, Sensors, Diagnostic Codes
Immobilizer System:
System Operation, Key Programming (if applicable), Troubleshooting
Harness And Wiring Diagram:
Complete Electrical Schematics for all Systems
Repair Procedures:
Step-by-step instructions for all covered systems
Diagnostic Procedures:
Troubleshooting charts, symptom-based diagnosis
Maintenance Procedures:
Oil changes, filter replacements, fluid checks, belt inspections
Adjustment Procedures:
Brake adjustment, clutch adjustment, parking brake adjustment
Installation Procedures:
Component replacement and installation guidelines
Depth:
Comprehensive (from basic maintenance to full rebuilds and diagnostics)
Oil Change Interval:
Typically 5,000 - 10,000 km or 6-12 months
Transmission Fluid Change:
Typically 40,000 - 80,000 km
Spark Plug Replacement:
Typically 40,000 - 100,000 km (depending on plug type)
Engine Oil Grade:
10W-30 or 10W-40 (typical for the era)
Coolant Type:
Ethylene Glycol based coolant, typically blue or green
Common Wear Items:
Clutch wear, exhaust system corrosion, suspension bushings, minor oil leaks
Potential Electrical Quirks:
Older vehicles may experience intermittent issues with body electrical components
