Engine Repair:
Detailed procedures for engine disassembly, assembly, diagnostics, and overhaul
Fuel System:
Carburetor adjustment and overhaul, fuel pump, fuel lines, and fuel tank service
Ignition System:
Ignition timing, spark plugs, distributor, coil, and ignition control module diagnostics
Cooling System:
Radiator, water pump, thermostat, hoses, and fan service
Lubrication System:
Oil pump, oil filter, oil pan, and lubrication passages
Exhaust System:
Exhaust manifold, pipes, muffler, and catalytic converter service
Transmission Manual:
Manual transmission disassembly, assembly, adjustment, and repair
Transmission Automatic:
Automatic transmission service, fluid checks, adjustments, and minor repairs (if applicable)
Clutch System:
Clutch disc, pressure plate, release bearing, and clutch linkage service
Drivetrain Rear Wheel Drive:
Driveshaft, U-joints, differential, and axle shafts
Suspension Front:
MacPherson struts, control arms, ball joints, tie rods, and sway bars
Suspension Rear:
Leaf springs or coil springs, shock absorbers, and trailing arms
Steering System:
Steering column, steering gear, tie rods, and power steering system (if equipped)
Brake System Front:
Disc brake calipers, pads, rotors, and brake lines
Brake System Rear:
Drum brake shoes, wheel cylinders, drums, and brake lines
Parking Brake:
Parking brake mechanism, cables, and adjustments
Electrical System Charging:
Alternator, voltage regulator, and battery service
Electrical System Starting:
Starter motor, starter solenoid, and ignition switch
Lighting System:
Headlights, taillights, turn signals, interior lighting, and related wiring
Instrument Panel:
Gauges, warning lights, and their associated sensors and wiring
Wiper Washer System:
Wiper motor, blades, linkage, and washer fluid reservoir/pump
HVAC System:
Heater core, blower motor, and vent controls
Body Interior:
Door panels, seat removal, dashboard trim, and carpeting
Body Exterior:
Bumpers, grille, fenders, hood, trunk lid, and doors
Glass Seals:
Windshield, rear glass, side glass replacement and seal service
Routine Maintenance:
Oil changes, filter replacements, fluid checks, tune-ups, lubrication
Troubleshooting Diagnostics:
Diagnostic flowcharts, symptom analysis, and common problem resolution
Repair Rebuild:
Component-level repair and complete overhaul procedures
Adjustment Calibration:
Alignment, timing, clutch, and brake adjustments
Wiring Diagrams:
Comprehensive electrical wiring diagrams for all systems
Torque Specifications:
Detailed torque values for critical fasteners
Depth Of Information:
In-depth, professional quality with detailed instructions, diagrams, and specifications
Oil Change Interval:
Every 3,000 - 5,000 miles or 3-6 months (recommendation varies based on driving conditions)
Air Filter Replacement:
Every 15,000 - 30,000 miles or as needed based on conditions
Spark Plug Replacement:
Every 20,000 - 30,000 miles
Engine Oil Specification:
API SF or SG, SAE 10W-30 or 10W-40 recommended (consult manual for exact spec)
Coolant Specification:
Ethylene glycol based antifreeze, typically a 50/50 mix with distilled water
Brake Fluid Specification:
DOT 3 (or equivalent)
Common Wear Items:
Ignition components (points, condenser, distributor cap/rotor), fuel pump diaphragm, suspension bushings, exhaust system corrosion
Electrical Gremlins:
Older wiring harnesses can degrade; issues with grounds, voltage regulators, and switches are not uncommon.
