Engine Mechanical:
Complete disassembly, inspection, repair, and reassembly of all engine components, including cylinder head, block, pistons, rings, crankshaft, camshaft, valvetrain, lubrication system, and cooling system.
Engine Performance:
Fuel injection system (EFI), ignition system, emission control systems, diagnosis of drivability issues.
Transmission Manual:
Service and repair of manual transmissions (e.g., 5-speed manual).
Transmission Automatic:
Service and repair of automatic transmissions (e.g., 4-speed automatic).
Drivetrain:
Transfer case, front and rear differentials, drive shafts, CV joints, axle shafts.
Suspension:
Front and rear suspension components, shock absorbers, springs, control arms, bushings, steering knuckles.
Steering:
Steering gear, power steering system, steering column, tie rods, ball joints.
Brakes:
Front and rear disc brake systems, brake calipers, rotors, pads, master cylinder, power brake booster, parking brake system.
Electrical System:
Battery, charging system (alternator, regulator), starting system (starter motor), lighting system, ignition system components.
Body And Frame:
Body panel repair, rust prevention, chassis components, doors, hood, tailgate, interior trim.
Heating And Air Conditioning:
HVAC system components, compressor, condenser, evaporator, heater core, climate controls.
Fuel System:
Fuel tank, fuel pump, fuel lines, fuel injectors, fuel pressure regulator.
Routine Maintenance:
Oil changes, filter replacements, fluid checks and top-offs, tire rotations, spark plug replacement, belt inspections and replacement.
Troubleshooting:
Systematic diagnostic procedures for common and complex issues across all vehicle systems.
Engine Repair:
Complete engine rebuilds, head gasket replacement, timing belt/chain service, component replacement.
Transmission Service:
Transmission fluid changes, seal replacements, clutch replacement (manual), major transmission repairs.
Brake Service:
Brake pad and rotor replacement, caliper service, brake fluid flush and bleeding, parking brake adjustment.
Electrical Diagnostics:
Wiring diagrams, component testing, circuit tracing, repair of electrical faults.
Suspension And Steering Repair:
Component replacement (shocks, ball joints, tie rods), alignment procedures, power steering pump and rack repair.
Body And Interior Repair:
Panel replacement, door mechanism repair, interior trim removal and installation.
Wiring Diagrams:
Detailed electrical wiring schematics for all major systems.
Depth Of Information:
Expert level, covering detailed diagnostic procedures and complete rebuilds suitable for professional technicians and advanced DIYers.
Oil Change Interval:
Every 3,000 - 5,000 miles or 3-6 months, depending on driving conditions and oil type.
Engine Air Filter Replacement:
Every 12,000 - 15,000 miles or annually.
Spark Plug Replacement:
Every 30,000 - 60,000 miles, depending on spark plug type (e.g., copper vs. platinum).
Transmission Fluid Change Auto:
Every 30,000 - 50,000 miles.
Engine Oil Type:
API Service SG, SH, or SJ; SAE 5W-30 or 10W-30 (check owner's manual for specific climate recommendations).
Coolant Type:
Ford Premium Engine Coolant or equivalent ethylene glycol-based antifreeze (50/50 mix with distilled water).
Brake Fluid Type:
DOT 3 Brake Fluid.
Power Steering Fluid Type:
Ford Power Steering Fluid or Mercon ATF.
Common Issues 1:
Rust (especially in wheel wells, rocker panels, and tailgate), U-joint wear, power steering leaks, cooling system issues (radiator, hoses), interior wear and tear.
Common Issues 2:
Transmission solenoid issues (automatic), exhaust manifold cracks (V8 engines if equipped), ABS sensor failures.
