Engine Service Repair:
Comprehensive engine overhaul, diagnostics, and repair procedures for all engine variants.
Transmission Service Repair:
Detailed repair and maintenance for the manual transmission, including clutch, gearbox, and final drive.
Brake System:
Front and rear brake system service, including discs, calipers, pads, lines, and ABS.
Wiring Diagram:
Detailed electrical wiring diagrams for all vehicle systems, essential for troubleshooting.
Electrical System:
Coverage of all electrical components, circuits, fuses, relays, and lighting.
Suspension:
Front and rear suspension geometry, component replacement, and alignment procedures.
Steering:
Power steering system, steering rack, column, and linkage maintenance and repair.
Cooling System:
Radiator, water pump, thermostat, hoses, and fan diagnostics and replacement.
Fuel Injection Fuel System:
Bosch Motronic fuel injection system, fuel pump, injectors, fuel lines, and evaporative emission control.
Emission System:
Exhaust system, catalytic converter, and emission control components and diagnostics.
Heater Air Conditional:
HVAC system diagnostics, refrigerant handling, climate control unit, and component replacement.
Engine Control System:
ECU (Engine Control Unit) functions, sensor diagnostics, and ignition system calibration.
Chassis Body:
Body repair, structural integrity, doors, hinges, latches, and exterior trim.
Restraint System:
Airbag system components, SRS control module, and seat belt service.
Interior:
Interior trim, seating, dashboard, console, and lighting service.
Differential Drive:
Front and rear differentials, driveshafts, and CV joints maintenance and repair.
Axle:
Front and rear axle components and servicing.
General Maintenance:
Routine checks, fluid changes, filter replacements, and general upkeep.
Troubleshooting:
Advanced troubleshooting guide for diagnosing and resolving common and uncommon issues.
Periodic Lubrication:
Scheduled lubrication points and specifications for chassis and driveline components.
Depth:
Complete factory-level repair and diagnostic information for professional technicians and experienced DIY enthusiasts.
Oil Change Interval:
Every 15,000 km (9,300 miles) or 12 months, whichever comes first
Spark Plug Replacement:
Refer to manual for specific intervals based on plug type; typically around 50,000-60,000 km
Engine Oil:
Refer to manual for specific viscosity (e.g., 5W-40 or 10W-40 synthetic recommended)
Coolant:
G12 (Purple) or equivalent ethylene glycol-based coolant with corrosion inhibitors
Transmission Fluid:
Refer to manual for specific manual transmission gear oil (e.g., GL-4 or GL-5 rated)
Common Issues:
Turbocharger wear, ignition coil failures, fuel injector issues, aging rubber components (hoses, bushings), ABS sensor faults.
