Engine:
AJ16 (3.2L, 4.0L), V12 (6.0L), 2.9L Engine - Including diagnostics, repair, overhaul, specifications
Cooling System:
Radiator, thermostat, coolant pump, hoses, fan system, diagnostics and repair procedures
Fuel System:
Fuel pump, injectors, fuel lines, pressure regulator, tank, diagnostics and repair
Emission Control:
Catalytic converter, O2 sensors, EVAP system, EGR system, emissions testing and repair
Engine Management:
ECU, sensors, actuators, ignition system, fuel control, diagnostic trouble codes (DTCs)
Exhaust System:
Manifolds, pipes, mufflers, catalytic converter replacement and repair
Clutch:
Clutch assembly, master cylinder, slave cylinder, hydraulic system, repair and adjustment (for manual transmission models)
Transmission Manual:
Gearbox overhaul, component replacement, fluid specifications, shifting mechanisms
Transmission Automatic:
ZF 4HP22, ZF 5HP30 - Torque converter, valve body, gearbox overhaul, fluid specifications, electronic control
Supercharger:
Supercharger unit, drive belt, intercooler, boost control systems (if applicable)
Driveshaft Final Drive:
Driveshafts, universal joints, CV joints, differential, axle bearings, fluid specifications
Steering:
Power steering rack, pump, hoses, steering column, linkages, alignment specifications
Suspension System:
Front and rear suspension, wishbones, coil springs, shock absorbers, bushings, anti-roll bars, alignment
Brakes:
Front and rear disc brakes, calipers, pads, rotors, hydraulic lines, ABS system, brake fluid specifications
Body Components And Trim:
Exterior panels, bumpers, doors, hood, trunk lid, glass, interior trim, upholstery, fasteners
Climate Control System:
HVAC unit, refrigerant, blower motor, heater core, A/C compressor, climate control module, diagnostics
Electrical:
Wiring diagrams, battery, alternator, starter, lighting system, fuses, relays, ignition switch, power windows, central locking
Security System:
Alarm system, immobilizer, keyless entry, central locking diagnostics and repair
Maintenance:
Oil changes, filter replacements, spark plug changes, fluid checks and top-ups, belt inspections and replacements, scheduled servicing
Troubleshooting:
Diagnostic procedures for all major systems, common fault identification, symptom-based troubleshooting guides
Repair:
Step-by-step repair instructions for component replacement, system overhauls, adjustments, and reassembly
Installation:
Fitting instructions for accessories and replacement parts
Body Repair:
Structural repair, panel replacement, dent repair, rust treatment, painting guidelines
Depth:
Comprehensive from basic maintenance to full engine and transmission rebuilds, including electrical diagnostics and body repair
Oil Change Interval:
Typically 10,000 miles or 12 months, refer to manual for specific engine and oil type recommendations.
Transmission Fluid Change:
Recommended at 60,000 miles or as specified for automatic and manual transmissions.
Engine Oil Type:
Viscosity grades such as 5W-30, 10W-40, or 15W-50 may be specified depending on climate and engine. Always consult manual.
Coolant Type:
Ethylene glycol-based antifreeze, typically a 50/50 mix with distilled water. Specific Jaguar-approved coolant recommended.
Brake Fluid Type:
DOT 3 or DOT 4 brake fluid
Automatic Transmission Fluid Type:
Dexron III (for ZF 4HP22) or specific ZF fluid (for ZF 5HP30). Refer to manual for precise identification.
Engine Cooling System:
Potential for radiator leaks, coolant hose degradation, and thermostat failure.
Electrical System:
Corrosion on connectors, alternator issues, and fuel pump relay failures can occur.
Suspension Components:
Wear in bushings, ball joints, and shock absorbers due to age and mileage.
Headliner:
Sagging headliner fabric is a common cosmetic issue.
