Engine Systems:
Engine block, pistons, rings, rods, crankshaft, oil pump, oil pan, ignition system, camshaft, valve train, cylinder head, head gasket, valve seals, valve springs, valve guides, piston pins, piston pin bushings, timing gear, crank pulley, freeze plugs, engine mounts, oil radiator, oil cooling system, PCV system.
Fuel System:
Fuel pump, fuel filter, fuel pipes, fuel tank cap, carburetor assembly, throttle shaft, choke shaft, choke valve, air filter, air filter replacement, air cleaner housing, fuel injector, fuel screen.
Exhaust System:
Muffler, downpipe, catalytic converter, exhaust gaskets, headers, heat wrap, manifold.
Cooling System:
Radiator, radiator fan, coolant hoses, fan shroud, AC condenser, heater system.
Transmission Drivetrain:
Transmission change, fluid change, clutch, pressure plate, clutch shoe, clutch case, transfer case, transfer plate, axle assembly, axle shafts, CV boots, shifter linkage, short shifter, shifter cable.
Brakes System:
Brakes, change brakes, brake pads, brake shoes, rotor, rotor replacement, brake discs, brake hoses, brake system, clutch lines.
Suspension Steering:
Suspension, suspension system, steering system, shocks, struts, wheel bolt pattern, wheel hubs.
Electrical System:
Ignition system, spark plugs, spark plug wires, wiring harness, engine harness, chassis wire harness, main wire harness, electrical pin connector, sensors, oil sensor, pressure sensor, oil pressure sensor, volt meter, relays (headlight, starter, ignition), alternator, alternator pulley, starter, battery, battery replacement, interior lighting, HID, projector headlights, taillights, bulb replacement, fog lights, third brake light, turn signals, side markers, courtesy light, door jamb switch, door lock, antenna, electrical wiring, torque specs.
Body Chassis:
Body plug, panel replacement, dashboard, dash replacement, door panels, glovebox, center console, console replacement, trim, trim replacement, bumper, front bumper, rear bumper, fender, doors, emblem, fuel cap, fuel door, grilles, front grille, hood, hood hinge, hood latch, jack, hoist, lifting, stands, mud guards, mud flaps, windshield, window regulator, door handle, wiper blade, wiper motor, washer pump, fuel tank cap, fuel filler neck.
Wheels Tires:
Tires, rotate tires, rotate tire, alignment, lug nuts, hub caps, wheel cover, tire replacement, flat repair.
Maintenance Procedures:
Oil change, transmission fluid change, routine maintenance, air filter replacement, fuel filter replacement, brake replacement, tire rotation, wheel alignment, battery replacement, spark plug replacement, coolant flush, belt replacement.
Repair Procedures:
Complete engine overhaul, carburetor repair and adjustment, transmission rebuild, clutch service, brake caliper and master cylinder service, suspension component replacement, electrical component diagnostics and repair, body panel repair and replacement, starter and alternator replacement.
Troubleshooting:
Diagnostic procedures for engine performance issues, electrical faults, transmission problems, braking system malfunctions, and suspension noise. Includes identification of common issues and their solutions.
Diagnostic Capabilities:
Advanced diagnostics, including detailed troubleshooting charts, fault code interpretation (where applicable to the era), and specific diagnostic procedures for various systems.
Rebuild Instructions:
Comprehensive rebuild instructions for major components such as the engine, transmission, and braking system, often including torque specifications and clearances.
Information Type:
Includes detailed diagrams, exploded views, technical specifications, torque values, fluid capacities, and step-by-step instructions.
Initial Service:
Manual will specify break-in period service (e.g., at 10 hours or 50 miles) including oil and filter change.
Regular Oil Change:
Typically every 3 months or 100 hours of operation, whichever comes first.
Air Filter Cleaning Replacement:
Recommended for cleaning every 50 hours and replacement every 100 hours or as needed based on operating conditions.
Transmission Fluid Change:
Generally every 6 months or 200 hours, manual will confirm.
Spark Plug Replacement:
Manual will provide specific interval, often around 500 hours for diesel glow plugs or standard spark plugs if gasoline.
Engine Oil Capacity:
Manual will specify exact capacity (e.g., 1.5-2.0 liters).
Coolant Type:
Manual will specify a specific type of antifreeze/coolant, typically a 50/50 mix of ethylene glycol and distilled water.
Common Wear Items:
Brake pads, tires, CV boots, and CVT belt are common wear items requiring periodic inspection and replacement.
Diesel Specific Considerations:
Cold weather starting (glow plug operation), fuel filter clogging (especially with poor fuel quality), and potential for exhaust soot build-up.
