Engine Mechanical:
Cylinder Head, Valves, Valve Train (Camshaft, Lifters, Springs, Locks), Piston and Rings, Connecting Rods, Crankshaft, Engine Block, Oil Pump, Oil Pan, Crankcase, Gaskets, Seals.
Fuel System:
Carburetor (including Carb Assembly, Diaphragm, Jets, Throttle Shaft, Choke Shaft/Valve), Fuel Pump, Fuel Filter, Fuel Lines, Fuel Tank Cap.
Ignition Components:
Ignition Coil, Spark Plugs, Spark Plug Wires, CDI Unit (assumed), Timing (Ignition Timing, Timing Gear, Crank Pulley).
Exhaust Components:
Muffler, Downpipe, Catalytic Converter (if applicable), Headers, Exhaust Gaskets, Heat Wrap.
Cooling Components:
Radiator, Radiator Fan, Oil Radiator/Oil Cooling System, Coolant Hoses, Fan Shroud.
Electrical Components:
Wiring Harness (Engine Harness, Chassis Wire Harness), Sensors (Oil Sensor, Pressure Sensor, Oil Pressure Sensor), Switches, Relays (Headlight Relay, Starter Relay, Ignition Relay), Battery, Alternator, Starter Motor.
Transmission Components:
Transmission Change, Fluid Change, Transfer Case, Transfer Plate, Axles, Axle Shafts, CV Boots, Hubs.
Clutch Components:
Clutch, Pressure Plate, Flywheel, Clutch Shoe, Clutch Case, Clutch Lines, Clutch Master Cylinder, Clutch Slave Cylinder (if hydraulic).
Brake Components:
Brakes, Change Brakes, Brake Pads, Brake Shoes, Rotor, Rotor Replacement, Brake Hose, Clutch Lines, Brake System Components.
Suspension Steering Components:
Shocks, Struts, Steering System, Suspension, Suspension System Components, Wheel Alignment, Rotate Tires.
Body Chassis Components:
Frame, Body Panels, Doors, Door Panels, Dashboard, Dash Replacement, Glovebox, Center Console, Interior Lighting, Trim, Bumper (Front/Rear), Fender, Grilles (Front Grille), Hood, Mud Guards/Flaps, Emblem, Fuel Door, Wiper Blades, Wiper Motor, Washer Pump.
Routine Maintenance:
Oil Change, Transmission Fluid Change, Fluid Changes, Air Filter Replacement, Spark Plug Replacement, Tire Rotation.
Engine Repair:
Engine Rebuild, Cylinder Head Service, Piston/Ring Replacement, Crankshaft Service, Valve Train Adjustment/Replacement, Camshaft Installation, Gasket Replacement, Seal Replacement.
Fuel System Repair:
Carburetor Overhaul/Adjustment, Fuel Pump Replacement, Fuel Filter Replacement, Fuel Line Service.
Ignition System Repair:
Spark Plug Wire Replacement, Ignition Coil Replacement, Ignition Timing Adjustment.
Exhaust System Repair:
Muffler Replacement, Header Installation, Exhaust Gasket Replacement.
Cooling System Repair:
Radiator Service, Fan Replacement, Coolant Hose Replacement.
Electrical System Repair:
Wiring Harness Repair/Replacement, Sensor Replacement, Starter Replacement, Alternator Replacement, Battery Service.
Transmission Drivetrain Repair:
Transmission Service, Transfer Case Service, Axle Repair, CV Boot Replacement.
Clutch System Repair:
Clutch Replacement, Flywheel Service, Clutch Hydraulic System Service.
Brake System Repair:
Brake Pad/Shoe Replacement, Rotor Replacement, Brake Line Service.
Suspension Steering Repair:
Shock/Strut Replacement, Steering Component Service, Suspension Component Replacement.
Body Chassis Repair:
Body Panel Replacement, Door Repair, Interior Trim Replacement, Bumper Replacement, Fender Repair.
Troubleshooting:
Diagnostic procedures, symptom analysis, and fault finding for all covered systems.
Depth Of Coverage:
Complete factory-level detail, including disassembly, reassembly, specifications, and troubleshooting.
Diagnostic Capabilities:
Detailed diagnostic procedures, torque specifications, electrical diagrams, and troubleshooting flowcharts.
Rebuild Procedures:
Comprehensive instructions for major component rebuilds (engine, transmission, etc.).
Initial Service:
First service typically at 600 miles or 6 months. Refer to manual for exact figures.
Engine Oil Change:
Every 1,000 miles or 6 months, whichever comes first. Refer to manual for precise intervals.
Air Filter Cleaning:
Every 600 miles or more frequently in dusty conditions. Replacement as needed.
Spark Plug Replacement:
Recommended at 3,000 miles or as needed based on condition. Refer to manual for specific type and gap.
Transmission Fluid Change:
Refer to manual for specific intervals, often at 2,000-3,000 miles or annually.
Engine Oil Specification:
Yamalube 4 (or equivalent SAE 10W-40 4-stroke motorcycle oil with API SG or higher).
Brake Fluid Specification:
DOT 3 or DOT 4 Hydraulic Brake Fluid.
Coolant Specification:
Ethylene Glycol based antifreeze (50/50 mix with distilled water) for a permanent type antifreeze.
Common Wear Items:
CV joints/boots, brake pads, air filter, spark plug.
Carburetor Tuning:
May require periodic cleaning and adjustment, especially after long storage or use in varied altitudes/conditions.
Belt Wear:
CVT belts are a wear item and require inspection for cracks, fraying, or excessive stretching. Replacement recommended based on mileage or visible wear.